TM-9-2815-210-34-2-1 LDS-465-1/LDS-465-2 Multifuel Engine Maintenance Manual Part 1
Page 2 of 259
WARNING SERIOUS OR FATAL INJURY TO PERSONNEL MAY RESULT IF THE FOLLOWING INSTRUCTIONS ARE NOT COMPLIED WITH. Engine weighs 1600 pounds. Do not use a chain hoist and lifting sling of less than two-ton capacity. Engine could fall and cause injury to personnel. Make sure lifting sling is pulled tight before taking mounting hardware out of engine mounting brackets in shipping container. Engine could slip off suspension frame and fall, causing injury to personnel. Smoking, sparks or open flame are not allowed within 50 feet of work area when drain- ing fuel. Fire or explosion could occur, causing injury to personnel and damage to equipment. Pressure plate assembly is heavy. It must be held firmly up and against flywheel when mounting screws are taken out. If it is not held up, it will fall and cause in- jury to personnel. Clutch disk is heavy enough to cause injury if dropped. It is held in place by pres- sure plate assembly. Do not let it fall out and drop when pressure plate assembly is taken out or it may cause injury to personnel. Flywheel housing is heavy. Be sure to hold it firmly up and against engine when taking off or putting on mounting nuts. It could fall off mounting studs and cause injury to personnel. Crankshaft damper and pulley assembly is heavy. Dropping it will cause damage to equipment and injury to personnel. Intake manifold and exhaust manifold assembly is heavy. Hold it up when taking off locknuts and washers or it may fall and cause injury to personnel. Starter assembly weighs fifty pounds. Be careful o hold it up firmly when taking it off mounting studs. Starter could fall and cause injury to personnel and damage to equipment.