TRANSFER CASE 30. Transfer case will not operate front differential ................. 0293 00-8 31. Transfer case will not operate rear differential ................. 0293 00-8 32. Transfer case leaks oil................................... 0293 00-8 33. Transfer case noisy ..................................... 0293 00-9 34. Transfer case grinds or pops out of gear during normal vehicle operation .......................................... 0293 00-9 DIFFERENTIAL 35. Differential noisy ...................................... 0293 00-9 36. Differential clunks during turns or initial takeoff ............... 0293 00-9 37. Differential leaks oil .................................... 0293 00-9 38. Differential leaks oil at companion flange ..................... 0293 00-10 TIRES AND WHEELS 39. Abnormal tire wear (front axle) ............................ 0293 00-10 40. Abnormal tire wear (rear axle) ............................. 0293 00-10 STEERING GEAR 41. Excessive play in steering ................................ 0293 00-10 42. Steering gear leaking oil ................................. 0293 00-11 43. Steering wheel hard to turn............................... 0293 00-11 WINCH 44. Clutch will not engage drum .............................. 0293 00-11 45. Winch noisy under load .................................. 0293 00-11 46. Drum overruns cable or cable coils loosen when paying out cable .... 0293 00-11 47. Winch does not hold load when power is released ............... 0293 00-11 48. Winch leaks oil ........................................ 0293 00-12 WINTERIZATION KITS 49. Heater fails to turn on .................................. 0293 00-12 50. Heater overheats – overheat switch is good .................... 0293 00-12 51. Heater overheats – continues to run ......................... 0293 00-12 52. Heater output too low ................................... 0293 00-12 53. Heater smokes and bangs when starting...................... 0293 00-12 54. Blower will not stop after turnoff ........................... 0293 00-12 55. Odor of fuel in ventilating air ............................. 0293 00-13 56. Blower runs, but heater fails to ignite........................ 0293 00-13 57. Heater smokes during normal operation ...................... 0293 00-13 MALFUNCTION NO. MALFUNCTION TROUBLESHOOTING PROCEDURE PAGE TM 9-2320-386-24-1-2 0292 00 DIRECT SUPPORT TROUBLESHOOTING PROCEDURES (CONTD) 0292 00-2 END OF WORK PACKAGE