TM-9-2350-261-20-1 Unit Maintenance Manual Volume 1 M113A2 M577A2 M1064 M1068 M1059 M901A1 Download
Page 28 of 1236
TM 9-2350-261-20-1 TABLE OF CONTENTS W P S e q u e n c e N o . Volume 1 WARNING SUMMARY HOW TO USE THIS MANUAL CHAPTER 1 — UNIT INTRODUCTORY INFORMATION WITH THEORY OF OPERATION GENERAL INFORMATION..............................................................................................................................0001 00 EQUIPMENT DESCRIPTION...........................................................................................................................0002 00 THEORY OF OPERATION................................................................................................................................0003 00 REPAIR PARTS, SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT................................................0004 00 CHAPTER 2 — UNIT TROUBLESHOOTING PROCEDURES INTRODUCTION HOW TO USE TROUBLESHOOTING..............................................................................0005 00 MALFUNCTION/SYMPTOM INDEX WP.......................................................................................................0006 00 ENGINE OVERHEATS......................................................................................................................................0007 00 ENGINE OVERCOOLS......................................................................................................................................0008 00 ENGINE DOES NOT CRANK...........................................................................................................................0009 00 ENGINE CRANKS SLOWLY............................................................................................................................0010 00 ENGINE CRANKS BUT WILL NOT START...................................................................................................0011 00 ENGINE CRANKS BUT WILL NOT START BELOW 40 (AIR BOX HEATER IS USED)........................................................................................................................................................0012 00 ENGINE RUNS ROUGH, STALLS, OR DOES NOT PUT OUT FULL POWER...........................................0013 00 ENGINE OIL LOW PRESSURE INDICATOR FAILS TO GO OFF AFTER ENGINE STARTS......................................................................................................................................................0014 00 ENGINE FUEL SYSTEM SCHEMATIC...........................................................................................................0015 00 STARTING SYSTEM SCHEMATIC..................................................................................................................0016 00 AIR BOX HEATER SYSTEM SCHEMATIC....................................................................................................0017 00 CHARGING SYSTEM MALFUNCTIONS.......................................................................................................0018 00 CONNECT/DISCONNECT ALTERNATOR (GENERATOR) TEST KIT........................................................0019 00 200 AMP CHARGING SYSTEM OPERATIONAL CHECK............................................................................0020 00 200 AMP CHARGE/REGULATION TROUBLESHOOTING..........................................................................0021 00 200 AMP FULL FIELD CHARGE TROUBLESHOOTING.............................................................................0022 00 200 AMP OVER VOLTAGE TROUBLESHOOTING.......................................................................................0023 00 100 AMP ENGINE CHARGING SYSTEM SCHEMATIC...............................................................................0024 00 200 AMP ENGINE CHARGING SYSTEM SCHEMATIC ..............................................................................0025 00 200 AMP ENGINE CHARGING SYSTEM SCHEMATIC (M981 ONLY)......................................................0026 00 DIFFERENTIAL HI OIL TEMP INDICATOR COMES ON.............................................................................0027 00 TRANSMISSION OIL HI TEMP INDICATOR COMES ON...........................................................................0028 00 NO EXTERIOR LIGHTS OPERATE.................................................................................................................0029 00 BLACKOUT DRIVE LIGHT DOES NOT WORK............................................................................................0030 00 ii