LO-9-2320-260-12 Lubrication Order for M113A2 M577A2 M106A2 M125A2 M1059 M1064 M1068 Download
Page 28 of 42
LUBRICATION ORDER LO 9-2350-261-12 10 July 1990 (Supersedes LO 9-2350-261-12, July 1985) NOTES CAUTION DO NOT use compressed air to dry filter, WARNING Damage will result. Fire resistant hydraulic (FRH) fluid may contain Tricresyl Phosphate which, if 2. HYDRAULIC TANK DRAIN. Drain hydrau- taken internally, can produce paralysis. lic system tank and service strainer every Hydraulic fluid may be absorbed through 1500 miles, semiannually, or when hy- the skin. Wear long sleeves, gloves, gog- draulic fluid type is changed. Drain hy- gles, and face shield. If FRH gets in eyes, draulic system tank as follows: wash them immediately and get medical a. Lower ramp (TM 9-2350-261-10). aid immediately. If FRH gets on your skin, b. Place suitable container of at least 2 thoroughly wash with soap and water. gallon capacity under drain elbow on Wash hands thoroughly prior to eating or bottom of tank, and remove plug. smoking. Application of these measures c. Disconnect hose at filter adapter el- is considered an effective control of the hazard. bow. Remove four machine bolts and key washers that secure filter adapter CAUTION to tank. Discard key washers. Remove Use only FRH hydraulic fluid. Do not mix filter and preformed packing from different types of fluid. Do NOT overfill. adapter. Discard packing. Wash adapt- er thoroughly in cleaning solvent (PD- 1, HYDRAULIC SYSTEM TANK. With ramp 680, Type II). down and carrier on level ground, check d. Clean interior of tank through the hydraulic fluid level. Fluid level should be adapter opening with dry cleaning sol- halfway in sight glass. To add hydraulic vent (PD-680, Type II) and clean cloth. fluid, remove fill plug and preformed e. Install new filter and packing on adapt- packing from top of tank. Add hydraulic fluid as needed. Install fill plug and new er. Secure adapter to tank with four new key washers and four machine preformed packing. bolts. Connect hose to adapter elbow. WARNING f. Fill tank with FRH fluid (2 quarts) to Dry cleaning solvent burns easily, can bring level between MAX and MIN cause skin rash, and can give off harmful marks. vapors. To avoid injury, keep away from g. Operate ramp and check for leaks. open fire and use in well-ventilated area. Wear protective clothing and rubber gloves. Change 1 CARD 21 of 32