TM-10-5411-205-13 HMMWV S-250/G Shelter Operator, Unit and Direct Support Download
Page 18 of 127
TM 10-5411-205-13 CHAPTER 3 UNIT MAINTENANCE INSTRUCTIONS Subject Section Page . Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I 3-1 Repair Parts, Special Tools, TMDE, and Support Equipment . . . . . . . . . . II 3-1 Service Upon ..Receipt . . . . . . . . . . . . . . . . . . . . . . . . . . . ........... . . . . . III 3-1 Troubleshooting . . . .... . ....... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . IV 3-7 Maintenance Procedures . . . . . . . .... . . . . . . . . . . . . . . . . . . . . . . . . . . V 3-11 Preparation for Shipment and Storage . . . . . . . . . . . . . . . . . . . . . . . . VI 3-70 Section I. LUBRICATION 3-1. Lubrication Inductions. Lubricate door hinges, latches and locking mechanisms, door brace assemblies, roof access steps, and lifting and towing bracket assemblies to prevent rust and corrosion. Check these parts frequently to be sure they are adequately lubricated. Lubricate with Solid Film Lubricant, MIL-L-23398 (Item 22, Appendix D). Section II. REPAIR PARTS. SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT Subject Common Tools . . . . . . . . . . . . . . . . . . . . . . Special Tools, TMDE, and Support Equipment . Repair Parts . . . . . . . . . . . . . . . . . . . . . . . . Para Page . . . . . . . . . . . . . . . . . . 3-2 3-1 . . . . . . . . . . . . . . . . . . 3-3 3-1 . . . . . . . . . . . . . . . . . . 3-4 3-1 3-2. Common Tools. A complete list of common tools and tool kits is given in Section III of Appendix B, Maintenance Allocation Chart. 3-3. Special Tools, TMDE, and Support Equipment. All special tools, TMDE, and support equipment are listed in Section III of Appendix B, Maintenance Allocation Chart, and in the Repair Parts and Special Tools List manual, TM 10-5411-205-23P, S-250/G Shielded and S-250/G Unshielded Electrical Equipment Shelters. 3-4. Repair Parts. Repair parts for unit maintenance of the shelter are listed and illustrated in TM 10-5411-205-23P. Section III. SERVICE UPON RECEIPT Subject Para Page Service Upon Receipt of Materiel . .. . . . . . . . . . . . . . . . . 3-5 3-1 Site Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6 3-7 3-5. Service Upon Receipt of Materiel. Inspect the shelter for damage incurred dur- ing shipment. If the shelter has been damaged, report the damage on SF 361 Transportation Discrepancy Report (TDR). If the drain plug has been loosened for shipment, tighten it. If the shelter is crated or pallet-mounted, refer to the end item technical manual for unpacking 3-1