TM-9-2320-366-20-3 MTV Unit Maintenance Manual M1083 Series - Volume 3 Download

TM 9-2320-366-20-3 INDEX-4 Change 2 SUBJECT INDEX (CONT) Subject Para D Dashboard WTEC II Cable Assembly Replacement/ Repair ........................................................... 7-10 WTEC III Cable Assembly Replacement/ Repair ........................................................... 7-11 Differential Axle Differential(s) Noisy ................................... 2-25 Fan and Differential Lock Solenoids Replacement ................................................. 7-24 Digitization Kit No Power to Digitization Rack ........................... 2-34 No Power to Driver Visual Enhancement (DVE) ........................................................... 2-34 No Power to Enhanced Position Location Reporting System (EPLRS) ............................ 2-34 No Power to Mobile Tracking system (MTS) ........ 2-34 No Power to Mobile Tracking System (MTS) Sense ........................................................... 2-34 No Power to Precision Lightweight Global Positioning System Receiver (PLGR) ............... 2-34 No Power to SINCGAR/Force XXI Battle Command Brigade and Below (FBCB) .............. 2-34 Dimmer Switch Replacement ......................................... 7-12 WTEC II Transmission ECU Pushbutton Shift Selector (TEPSS) Dimmer Module Replacement ................................................. 7-13 Diode Circuit Breaker, Diode, and Relay Replacement ................................................... 7-9 Disassembly General Disassembly Instructions ...................... 2-41 Disconnecting/Connecting Batteries ...................... 7-57 Display Lighted Indicator Display Replacement/ Repair ........................................................... 7-16 Door Left-Hand Door and Cab Marker lights Cable Assembly Replacement ................ 7-61 Right-Hand Door and Cab Marker lights Cable Assembly Replacement ................ 7-64 Drive Belt and Tension Pulley Replacement ................................................... 6-13 Drum M1089 LH or RH 30K Winch Cable Drum Tensioner Does Not Operate ........................... 2-37 Dump Body Does Not Lower ....................................... 2-32 Body Does Not Raise ....................................... 2-32 Body Drifts Down From Raised Position ............. 2-32 Body Hydraulic System Troubleshooting ............ 2-32 M1090/M1094 Dump Body Switch Replacement/Adjustment ................................ 7-23 Subject Para E ECU Central Tire Inflation System (CTIS) ECU Indicates No Fault Code But System Fails to Inflate or Deflate ............................... 2-24 Five Central Tire Inflation System (CTIS) ECU Indicator Lights Flashing ............... 2-24 Four CTIS ECU Indicator Lights Flashing ........................................................ 2-24 Frequency ECU Replacement ........................... 7-31 Two Steady Modes Lights Illuminate on Central Tire Inflation System (CTIS) ECU ................................................... 2-24 Windshield Wiper ECU Replacement ................. 7-69 WTEC II Transmission ECU Pushbutton Shift Selector (TEPSS) Dimmer Module Replacement ...................................... 7-13 Electrical Gages Replacement .............................. 7-14 EMI Windshield Washer Pump Electromagnetic Interference (EMI) Cable Assembly Replacement ................................................. 7-67 Windshield Wiper Electromagnetic Interference (EMI) Cable Replacement ................................................. 7-68 Engine and Transmission Oil Sampling Valves Replacement ................................................... 3-6 Fan and Fan Clutch Assembly Replacement ................................................. 6-14 Maintenance Introduction .................................... 3-1 Speed Sensor Replacement/ Adjustment .................................................... 7-46 Ether Sensor Replacement ........................................ 7-47 Starting Aid Replacement ................................. 4-15 Exhaust Muffler and Exhaust Heat Shields Replacement ................................................... 5-2 Pipe Replacement .............................................. 5-3 System Maintenance Introduction ........................ 5-1 External No Service or External Hydraulic Power From M1089 .................................................. 2-33 F Fan and Differential Lock Solenoids Replacement ................................................. 7-24 Engine Fan and Fan Clutch Assembly Replacement ................................................. 6-14 Radiator Fan Shrouds Replacement ..................... 6-4