TM-9-2320-365-20-1 LMTV Unit Maintenance Manual M1078 Series - Volume 1 Download
Page 1627 of 1760
TM 9-2320-365-20-1 Change 2 INDEX-11 Subject Para E (Cont) ECU (Cont) Four CTIS ECU Indicator Lights Flashing ........................................................ 2-24 Frequency ECU Replacement ........................... 7-28 M1079 Air Conditioner ECU Connector Replacement ................................................ 16-47 Windshield Wiper ECU Replacement ................... 7-62 WTEC II Transmission ECU Pushbutton Shift Selector (TEPSS) and Bracket Replacement and Calibration ............................. 8-2 WTEC II Transmission ECU Pushbutton Shift Selector (TEPSS) Dimmer Module Replacement ................................................. 7-13 WTEC II Transmission ECU Pushbutton Shift Selector (TEPSS) Illumination Does Not Dim ................................................ 2-16 WTEC III Transmission ECU Replacement ................................................... 8-7 Electrical Gages Replacement ......................................... 7-14 Introduction, Electrical System Maintenance .................................................... 7-1 System ........................................................... 1-14 System Does Not Maintain a Charge ................. 2-16 System Troubleshooting ................................... 2-16 Emergency Cab Lift Procedure ............................................ 19-8 Gladhand Two-Way Check Valve Replacement ................................................ 11-24 M1079 Blackout/Emergency Light Replacement ................................................ 16-58 M1079 Emergency Light(s) Does Not Operate ......................................................... 2-16 EMI Windshield Washer Pump Electromagnetic Interference (EMI) Cable Assembly Replacement ........................ 7-60 Windshield Wiper Electromagnetic Interference (EMI) Cable Replacement ................................................. 7-61 Engine Air Intake System ............................................ 1-11 And Transmission Oil Sampling Valves Replacement ................................................... 3-6 Control Cable Assembly Replacement ............... 7-72 Coolant In Engine Lubrication Oil ....................... 2-12 Cranks But Does Not Start ................................ 2-12 Cranks But Does Not Start ................................ 2-16 Cranks But Does Not Start or Engine Stalls After Starting ............................. 2-13 Does Not Crank ............................................... 2-12 Does Not Crank ............................................... 2-16 Excessive Black or Gray Exhaust Smoke ............................................. 2-12 Excessive Engine Oil Consumption ................. 2-12 Subject Para E (Cont) Engine (Cont) Exhaust System Unusually Noisy or Vibrates Excessively During Engine Operation ...................................................... 2-14 Fan and Fan Clutch Assembly Replacement ................................................. 6-14 Fan Does Not Turn Off Using Radiator Fan Off Switch ............................................... 2-16 Fan Runs Constantly ........................................ 2-16 High Engine Temperature Indicator Does Not Operate .......................................... 2-16 High Engine Temperature Indicator Illuminates ..................................................... 2-16 Introduction, Engine Maintenance ........................ 3-1 Low Engine Oil Pressure ................................... 2-12 Low Engine Power ............................................ 2-12 Master Power Switch Does Not Shut Down Engine ................................................. 2-16 Oil Pressure Gage Does Not Operate or Is Inaccurate .............................................. 2-16 Oil Pressure Indicator Does Not Operate ......................................................... 2-16 Overheats ........................................................ 2-12 Overheats ........................................................ 2-15 Overspeeds on Start ......................................... 2-12 Speed Sensor Replacement/ Adjustment .................................................... 7-38 Stalls at Low RPM ........................................... 2-12 System Troubleshooting ................................... 2-12 Too Much Engine Vibration ............................... 2-12 Transmission Engine Speed Sensor Replacement ................................................. 7-43 Equipment Characteristics, Capabilities, and Features ................................................... 1-7 Ether Sensor Replacement ........................................ 7-39 Start Switch Does Not Illuminate ....................... 2-16 Start Does Not Operate .................................... 2-16 Starting Aid Does Not Operate .......................... 2-13 Starting Aid Replacement ................................. 4-15 Excessive Black or Gray Exhaust Smoke .......................... 2-12 Braking Distance .............................................. 2-20 Condensation in Fuel ........................................ 2-16 Engine Oil Consumption ................................... 2-12 Play When Turning Steering Wheel .................... 2-26 Exhaust Excessive Black or Gray Exhaust Smoke .......................................................... 2-12 Fumes in Cab .................................................. 2-14 Introduction, Exhaust System Maintenance .................................................... 5-1 Muffler and Exhaust Heat Shields Replacement ................................................... 5-2 Pipe Replacement .............................................. 5-3 System Troubleshooting ................................... 2-14